6-Week Facility AuditAuditoría de 6 Semanas

Burly Botanicals · Irrigation, Climate & Feeding Burly Botanicals · Riego, Clima y Fertilización

2026-04-01 → 2026-05-13 · Coco 2-gal Char-Coir · 5 flower cycles spanning every phase (stretch, bulking, ripening, dry) 2026-04-01 → 2026-05-13 · Coco Char-Coir 2 gal · 5 ciclos de flor cubriendo cada fase

FacilityBurly Botanicals · AROYA 3920 OwnerMichael Fayak (feed / EC) GrowerBrittany Durham (climate / VPD, since Feb 2026) Emitters2 GPH × 2 per plant LightingUCL 600 + UC ~660 PPFD + CO₂ SubstrateCoco 2-gal Char-Coir bag

Headline FindingsHallazgos Principales

Substrate EC · Cycle 40 bulkingCE en sustrato · Ciclo 40 engorde

1.98 mS

vs 4.0–7.0 target · 50% below floorvs objetivo 4.0–7.0 · 50% por debajo

VPD lights-on · Cycle 40VPD luces-on · Ciclo 40

1.04 kPa

vs 1.2–1.4 target · at lower edgevs objetivo 1.2–1.4 · en el borde inferior

Overnight dryback · Cycle 40Dryback nocturno · Ciclo 40

19% median

vs 12–18% target · upper edgevs objetivo 12–18% · borde superior

Inverse temp differentialDiferencial térmico invertido

29/43 days

lights-off WARMER than lights-onnoche más cálida que día

Computed alerts in 6 weeksAlertas calculadas en 6 semanas

guardrails too loose to fireguardarrieles demasiado laxos

P0 delay shift post-5/8Cambio P0 post-5/8

↑ 61 min

Cycle 39 222→283 min · direction rightCiclo 39 222→283 min · dirección correcta

The leadEl titular

The May 8 substrate-EC-collapse story is still active. In the only room with full sensor data — Flower East A (Cycle 40, Wk 4 Mega Pump) — substrate EC is running mean 1.98 mS across 28 days vs the 4.0–7.0 bulking target. Brittany's lowered VPDs are sticking (1.04 lights-on, low end of band) but feed EC was not pushed up to compensate, so transpiration is starved and the substrate EC stack never built. Post-5/8 irrigation events DID shift in the committed direction (fewer shots, longer P0/P3 across all 3 priority cycles), but the magnitude has likely over-corrected for bulking and stretch — they are now under-irrigated, not just steered. AROYA dashboard reads "green" because pore_ec target_min in config is still 3.0 and soil_moist alert bands are wide open (alert_max=77). Zero computed alerts fired across the whole 6 weeks. La historia del colapso de CE en sustrato del 8 de mayo sigue activa. En la única sala con datos completos de sensores — Flower East A (Ciclo 40, Sem 4 Mega Pump) — la CE en sustrato promedia 1.98 mS en 28 días vs objetivo 4.0–7.0 para engorde. Los VPDs reducidos de Brittany se mantienen (1.04 luces-on, borde bajo) pero la CE de fertilización no se subió para compensar, por lo que la transpiración está hambrienta y nunca se construyó la pila de CE en sustrato. Los eventos de riego post-5/8 SÍ se desplazaron en la dirección comprometida (menos shots, P0/P3 más largos en los 3 ciclos prioritarios), pero la magnitud probablemente se sobrecorrigió para engorde y estiramiento — ahora están subriegados, no solo guiados. El dashboard de AROYA lee "verde" porque pore_ec target_min en config sigue en 3.0 y las bandas de alerta de soil_moist están totalmente abiertas (alert_max=77). Cero alertas calculadas activadas en las 6 semanas.

May 8 Commitments — Did They Stick?Compromisos del 8 de Mayo — ¿Se Mantuvieron?

Cian's May 8 1:1 with Michael Fayak captured 5 explicit commitments. The audit lens evaluates each against the 6-week dataset.El 1:1 de Cian con Michael Fayak el 8 de mayo capturó 5 compromisos explícitos. La auditoría evalúa cada uno contra el dataset de 6 semanas.

CommitmentCompromiso	Evidence in dataEvidencia en datos	VerdictVeredicto
Raise feed EC 1.9–2.4 → 2.3–2.6, push 2.8Subir CE fert. 1.9–2.4 → 2.3–2.6, empujar 2.8	No target_ranges row with startDate ≥ 5/8 touches pore_ec or feed_ec bounds. AROYA doesn't expose batch-tank EC directly; needs front-end / on-site confirmation.Ningún registro de target_ranges con startDate ≥ 5/8 toca límites pore_ec o feed_ec. AROYA no expone CE del tanque directamente; requiere confirmación en front-end / sitio.	⨯ Not in configNo en config
Stop chasing runoff on every shotDejar de perseguir runoff en cada shot	All 3 cycles dropped shots/day post-5/8 (C40 3.4→2.0, C39 3.9→1.5, C41 5.9→3.0). P0 lengthened on C39+C41. Direction matches commitment.Los 3 ciclos bajaron shots/día post-5/8 (C40 3.4→2.0, C39 3.9→1.5, C41 5.9→3.0). P0 alargado en C39+C41. Dirección coincide.	~ Over-correctedSobrecorregido
Substrate EC ≥2.0 veg / ≥feed+1.0 flowerCE sustrato ≥2.0 veg / ≥fert+1.0 flor	C40 (bulking) substrate EC mean 1.98, range 0.93–2.96 across 28 days. Target was 4.0–7.0. 50% below floor.CE sustrato C40 (engorde) promedio 1.98, rango 0.93–2.96 en 28 días. Objetivo 4.0–7.0. 50% bajo el piso.	⨯ Not implementedNo implementado
Drip-drain mounted under tableDrip-drain montado bajo la mesa	No API signal. Chrome MCP not connected so front-end confirmation blocked.Sin señal en API. Chrome MCP desconectado, confirmación front-end bloqueada.	? UnknownDesconocido
Pre-harvest pull to ~1.0 substrate EC final weekBajar a ~1.0 CE sustrato semana final	C39 (Wk 7→8 flush) cannot be measured — room 12404 readings missing. Event shape shows ramp-down but Wk 5→6 cliff is too early (3.2→1.3 shots/d).C39 (Sem 7→8 flush) no medible — datos de sala 12404 ausentes. La forma del evento muestra rampa-abajo pero el acantilado Sem 5→6 es muy temprano (3.2→1.3 shots/día).	? Partial / unknownParcial / desconocido

Per-Room Deep Dive · Select & CompareAnálisis por Sala · Selecciona y Compara

Click a room chip to view its 6-week trajectory. Hold Shift or click "Compare mode" to overlay multiple rooms. Target bands shade automatically based on the selected room's current phase.Haz clic en un chip de sala para ver su trayectoria de 6 semanas. Mantén Shift o haz clic en "Modo comparar" para superponer varias salas. Las bandas objetivo se sombrean automáticamente según la fase actual de la sala seleccionada.

Substrate EC · pore_ec daily meanCE en sustrato · pore_ec media diaria

Overnight relative dryback % · dailyDryback relativo nocturno % · diario

VPD lights-on vs lights-off · dailyVPD luces-on vs luces-off · diario

Air temp lights-on vs lights-off · dailyTemp. aire luces-on vs luces-off · diario

Phase Biophysics & Irrigation InputsBiofísica y Entradas de Riego por Fase

For each room and phase: drip volume, drain volume, drip/drain EC, runoff ratio, EC stack delta, daily field capacity (FC) and VWC floor averages, evapotranspiration rate (% VWC loss per hour during dryback), DLI, CO₂, VPD-stress hours, day-night temperature differential (DIF), and substrate temperatures. All numbers are 6-week zone-aggregate stats across 2026-04-01 → 2026-05-13 (12-zone average per room). Target bands are phase-specific. Feed pH (5.6–5.8) and runoff pH (5.8–6.2) targets are listed but AROYA does not capture pH — those require lab/probe verification.Para cada sala y fase: volumen drip, volumen drain, CE drip/drain, ratio runoff, delta pila CE, promedios diarios de capacidad de campo (FC) y piso VWC, tasa de evapotranspiración (% pérdida VWC/hr durante dryback), DLI, CO₂, horas de estrés VPD, diferencial térmico día-noche (DIF), y temperaturas de sustrato. Todos los números son agregados de 6 semanas por zona en 2026-04-01 → 2026-05-13. Objetivos pH de fertilización (5.6–5.8) y runoff (5.8–6.2) listados pero AROYA no captura pH — requieren laboratorio.

Flower East A1-A4 · Cycle 40

Cycle 40 has the only continuous 6-week sensor record. The data shows a textbook generative cascade: ET rate climbed 0.4→1.7 %/hr Wk 1→Wk 4, DLI ramped 28→39 mol/m²/d, CO₂ supplementation climbed 1474→1711 ppm. Drip-drain (12 zones aggregated over 6w): drip 2,780 mL, drain 891 mL → 32.0% runoff (slightly above 20–30% bulking target). Drip EC 2.10 mS is BELOW Michael's 2.3–2.6 commitment. EC stack delta is +0.56 mS (drain higher than drip) which is correct direction but small — substrate pore_EC sits at 2.96 mS, far below the 4–7 mS bulking target. This is the May 8 chain still active.El Ciclo 40 tiene el único registro continuo de 6 semanas. Los datos muestran una cascada generativa de manual: ET subió 0.4→1.7 %/hr de Sem 1→Sem 4, DLI 28→39 mol/m²/d, CO₂ 1474→1711 ppm. Drip-drain (12 zonas agregadas en 6sem): drip 2,780 mL, drain 891 mL → 32.0% runoff. CE drip 2.10 mS BAJO el compromiso de Michael 2.3–2.6. Delta de pila +0.56 mS — sustrato pore_EC en 2.96 mS, muy bajo el objetivo 4–7 mS de engorde.

DRIP-DRAIN · 6-week zone aggregate (n_zones=12) · period 2026-04-01 → 2026-05-13DRIP-DRAIN · agregado por zona 6 semanas

Metric	Observed (mean · zone range)	Target (Wk 4 Mega Pump (bulking))	Status
Drip volume (DFI)Volumen drip (DFI)	2781 mL 2208–3436	—	raw input
Drain volume (DFI_drain)Volumen drain (DFI_drain)	891 mL 527–1257	—	raw output
Drain / drip ratio (runoff %)Ratio drain / drip	32.0%	20–30%	above target
Drip EC (feed)CE drip (fertilización)	2.10 mS 1.88–2.73	2.5–3.0 mS	below target
Drain EC (runoff)CE drain (runoff)	2.66 mS 2.15–3.67	4.0–7.0 mS	below target
Substrate EC (pore_ec)CE sustrato (pore_ec)	2.96 mS 2.75–3.22	4.0–7.0 mS	between drip & drain
EC stack Δ (drain − drip)Δ pila CE (drain − drip)	+0.56 mS	+1.0 to +5.0 mS	+0.56 mS weak stack
Feed pH targetObjetivo pH fert.	not in AROYA	5.6–5.8	manual / lab
Runoff pH targetObjetivo pH runoff	not in AROYA	5.8–6.2	manual / lab

PER-PHASE BIOPHYSICS (6-week aggregates, daily-mean basis)BIOFÍSICA POR FASE (agregados 6 semanas)

Phase	FC daily mean	Floor daily mean	ET rate (%/hr dryback)	DLI (mol/m²/d)	VPD-stress hrs/d	DIF (°F)	CO₂ lights-on (ppm)	VPD lights-on (kPa)	Soil temp on / off (°F)
Veggie Tails (14d)	—	—	—	28.0 14.9–36.8	0.0h 0.0–0.0	0.99°F 0.51–1.94	1474 1290–1727	1.08 ±0.184	—
Wk 1 Transition (7d)	72.5% 68.3–74.9	62.0% 59.5–64.8	0.40 %/hr -0.76–1.01	32.7 30.2–37.0	0.0h 0.0–0.0	0.70°F 0.24–0.96	1509 1422–1713	0.99 ±0.128	—
Wk 2 Early Gen (7d)	73.4% 72.5–73.7	55.1% 50.8–61.5	1.70 %/hr 0.80–2.12	34.7 31.4–37.5	0.0h 0.0–0.0	0.56°F 0.13–0.90	1654 1322–2000	1.04 ±0.082	—
Wk 3 Late Gen (8d)	74.0% 73.2–74.8	54.9% 51.3–61.6	1.57 %/hr 0.96–1.88	38.9 34.9–40.6	0.0h 0.0–0.0	0.42°F -0.08–0.61	1686 1398–2000	1.04 ±0.082	—
Wk 4 Mega Pump (bulking) (7d)	74.2% 73.5–74.6	54.1% 52.8–55.5	1.63 %/hr 1.52–1.75	33.2 31.3–35.4	0.0h 0.0–0.0	0.34°F 0.06–0.98	1711 1395–2000	1.03 ±0.105	—

CURRENT PHASE TARGETS · Wk 4 Mega Pump (bulking)OBJETIVOS DE FASE ACTUAL · Wk 4 Mega Pump (bulking)

Feed/Drip EC: 2.5–3.0 mS Drain EC: 4.0–7.0 mS Feed pH: 5.6–5.8 Runoff pH: 5.8–6.2 Runoff %: 20–30% Dryback: 12–18% VPD lights-on: 1.2–1.4 kPa DIF: 2–4°F DLI: 38–48 mol/m²/d CO₂: 1200–1700 ppm ET rate target: 1.4–2.2 %/hr

Flower East B1-B4 · Cycle 39

Cycle 39 entered the audit in Wk 6 Pump/Ripen and is now Wk 8 Flush. The flush is correctly executing: drip EC 0.99 mS (in flush target 0.5–1.5), drain EC 1.22 mS, substrate pulling to 1.78 mS. Drain ratio at 52.4% is in target for flush. ET rate 1.55→1.82 %/hr matches healthy ripening transpiration. VPD-stress hours 1.9/day in Wk 6 indicate generative push working. This is the room where May 8 commitments are visibly closest to landing — the controller and the data finally agree.Ciclo 39 entró en Sem 6 Pump/Ripen y ahora Sem 8 Flush. El flush ejecutando correctamente: CE drip 0.99 mS (en objetivo 0.5–1.5), CE drain 1.22 mS, sustrato tirando a 1.78 mS. Ratio drain 52.4% en objetivo flush. ET 1.55→1.82 %/hr — transpiración saludable de maduración. Estrés VPD 1.9 hrs/d en Sem 6 = empuje generativo funcionando. Sala donde compromisos del 8/5 están visiblemente más cerca.

DRIP-DRAIN · 6-week zone aggregate (n_zones=12) · period 2026-04-01 → 2026-05-13DRIP-DRAIN · agregado por zona 6 semanas

Metric	Observed (mean · zone range)	Target (Wk 8 Flush)	Status
Drip volume (DFI)Volumen drip (DFI)	3352 mL 1572–4355	—	raw input
Drain volume (DFI_drain)Volumen drain (DFI_drain)	1756 mL 659–3893	—	raw output
Drain / drip ratio (runoff %)Ratio drain / drip	52.4%	30–50%	above target
Drip EC (feed)CE drip (fertilización)	0.99 mS 0.83–1.53	0.5–1.5 mS	in band
Drain EC (runoff)CE drain (runoff)	1.22 mS 0.84–2.43	0.8–2.0 mS	in band
Substrate EC (pore_ec)CE sustrato (pore_ec)	1.78 mS 1.44–2.64	0.8–2.0 mS	between drip & drain
EC stack Δ (drain − drip)Δ pila CE (drain − drip)	+0.23 mS	+1.0 to +5.0 mS	+0.23 mS flat
Feed pH targetObjetivo pH fert.	not in AROYA	5.6–5.8	manual / lab
Runoff pH targetObjetivo pH runoff	not in AROYA	5.8–6.2	manual / lab

PER-PHASE BIOPHYSICS (6-week aggregates, daily-mean basis)BIOFÍSICA POR FASE (agregados 6 semanas)

Phase	FC daily mean	Floor daily mean	ET rate (%/hr dryback)	DLI (mol/m²/d)	VPD-stress hrs/d	DIF (°F)	CO₂ lights-on (ppm)	VPD lights-on (kPa)	Soil temp on / off (°F)
Wk 6 Pump/Ripen (7d)	72.3% 70.4–74.4	57.4% 52.4–61.9	1.55 %/hr 1.09–2.01	—	1.9h 0.0–10.0	1.06°F 0.70–1.71	—	1.25 ±0.226	—
Wk 8 Flush (4d)	74.2% 74.0–74.5	53.6% 52.4–54.7	1.82 %/hr 1.69–1.91	—	0.0h 0.0–0.0	—	—	0.95 ±0.062	—

CURRENT PHASE TARGETS · Wk 8 FlushOBJETIVOS DE FASE ACTUAL · Wk 8 Flush

Feed/Drip EC: 0.5–1.5 mS Drain EC: 0.8–2.0 mS Feed pH: 5.6–5.8 Runoff pH: 5.8–6.2 Runoff %: 30–50% Dryback: 25–35% VPD lights-on: 1.4–1.6 kPa DIF: 3–5°F DLI: 30–40 mol/m²/d CO₂: 0–800 ppm ET rate target: 1.8–2.8 %/hr

Flower Westt A1-A4 · Cycle 41

Cycle 41 flipped to flower 4/9 (Wk 1 Transition / stretch). **CRITICAL FINDING:** Drain EC 2.17 mS is LOWER than drip EC 2.41 mS — that's a NEGATIVE EC stack delta (-0.24 mS). For stretch, you want aggressive STACKING (drain EC ≥ drip + 1 to + 5). Substrate pore_EC is 1.23 mS — far below the 6–12 mS stretch target. Drain ratio 19.8% is at the low edge. Some sensor zones show readings dropping to 0–1 (intermittent disconnects) — flag for service. Cycle 41 is not getting its generative push.Ciclo 41 cambió a flor el 4/9 (Sem 1 Transición / estiramiento). **HALLAZGO CRÍTICO:** CE drain 2.17 mS es MENOR que CE drip 2.41 mS — delta pila NEGATIVO (-0.24 mS). Para estiramiento, necesitas APILAMIENTO agresivo (drain ≥ drip + 1 a + 5). Sustrato pore_EC en 1.23 mS — muy bajo el objetivo 6–12 mS. Ratio drain 19.8% borde bajo. Sensores con desconexiones intermitentes — alertar servicio.

DRIP-DRAIN · 6-week zone aggregate (n_zones=12) · period 2026-04-09 → 2026-05-13DRIP-DRAIN · agregado por zona 6 semanas

Metric	Observed (mean · zone range)	Target (Cycle 41 Wk 1 Transition (stretch))	Status
Drip volume (DFI)Volumen drip (DFI)	664 mL 60–1069	—	raw input
Drain volume (DFI_drain)Volumen drain (DFI_drain)	131 mL 0–353	—	raw output
Drain / drip ratio (runoff %)Ratio drain / drip	19.8%	15–25%	in band
Drip EC (feed)CE drip (fertilización)	2.41 mS 1.67–5.01	3.0–3.5 mS	below target
Drain EC (runoff)CE drain (runoff)	2.17 mS 0.68–7.18	6.0–12.0 mS	below target
Substrate EC (pore_ec)CE sustrato (pore_ec)	1.23 mS 0.80–1.61	6.0–12.0 mS	between drip & drain
EC stack Δ (drain − drip)Δ pila CE (drain − drip)	-0.24 mS	+1.0 to +5.0 mS	-0.24 mS NEGATIVE — substrate not concentrating
Feed pH targetObjetivo pH fert.	not in AROYA	5.6–5.8	manual / lab
Runoff pH targetObjetivo pH runoff	not in AROYA	5.8–6.2	manual / lab

PER-PHASE BIOPHYSICS (6-week aggregates, daily-mean basis)BIOFÍSICA POR FASE (agregados 6 semanas)

Phase	FC daily mean	Floor daily mean	ET rate (%/hr dryback)	DLI (mol/m²/d)	VPD-stress hrs/d	DIF (°F)	CO₂ lights-on (ppm)	VPD lights-on (kPa)	Soil temp on / off (°F)
Cycle 41 Wk 1 Transition (stretch) (8d)	61.9% 1.6–74.6	46.3% 1.2–67.6	-23.30 %/hr -167.24–1.09	—	0.0h 0.0–0.0	-0.40°F -1.35–0.84	—	1.14 ±0.135	—

CURRENT PHASE TARGETS · Cycle 41 Wk 1 Transition (stretch)OBJETIVOS DE FASE ACTUAL · Cycle 41 Wk 1 Transition (stretch)

Feed/Drip EC: 3.0–3.5 mS Drain EC: 6.0–12.0 mS Feed pH: 5.6–5.8 Runoff pH: 5.8–6.2 Runoff %: 15–25% Dryback: 20–30% VPD lights-on: 1.0–1.2 kPa DIF: 3–5°F DLI: 28–38 mol/m²/d CO₂: 1200–1700 ppm ET rate target: 1.0–1.8 %/hr

Flower West B1-B4 · Cycle 38 Dry

Dry room. Climate-only data (no substrate sensors active in dry). VPD running 1.10 ± 0.08 — slightly high for a slow terpene-preserving dry (target 0.6–1.0). DIF slightly negative (-0.4°F) is fine for dry. Only 4 days of data available — re-run when bridge stabilizes for trend confidence.Sala de secado. Solo datos de clima. VPD en 1.10 ± 0.08 — algo alto para secado lento preservando terpenos (objetivo 0.6–1.0). DIF ligeramente negativo (-0.4°F) está bien. Solo 4 días de datos.

DRIP-DRAINDRIP-DRAIN

Dry room — no irrigation hardware

PER-PHASE BIOPHYSICS (6-week aggregates, daily-mean basis)BIOFÍSICA POR FASE (agregados 6 semanas)

Phase	FC daily mean	Floor daily mean	ET rate (%/hr dryback)	DLI (mol/m²/d)	VPD-stress hrs/d	DIF (°F)	CO₂ lights-on (ppm)	VPD lights-on (kPa)	Soil temp on / off (°F)
Cycle 38 Dry (4d)	—	—	—	—	0.0h 0.0–0.0	-0.40°F -0.77–-0.02	—	1.10 ±0.082	—

CURRENT PHASE TARGETS · Cycle 38 DryOBJETIVOS DE FASE ACTUAL · Cycle 38 Dry

Feed/Drip EC: N/A mS Drain EC: N/A mS Feed pH: 5.6–5.8 Runoff pH: N/A Runoff %: N/A% Dryback: N/A% VPD lights-on: 0.6–1.0 kPa DIF: 0–2°F DLI: N/A mol/m²/d CO₂: 0–500 ppm ET rate target: N/A %/hr

MOM / PROP

MOM / PROP — 175 plants. CO₂ at 4050 ppm during lights-on is **near the 5000 ppm hard ceiling** — extremely aggressive for a veg room. Substrate pore_EC 1.70 mS (zones 1.27–2.12) is below mother target 3–5. ET rate 0.11 %/hr — appropriate for mothers (don't transpire like flower canopy). VPD 0.69 kPa — at low edge of veg band. **No drip-drain station in this room** — only substrate pore_EC sensors, so drip/drain volumes cannot be reported.MOM/PROP — 175 plantas. CO₂ a 4050 ppm en luces-on cerca del techo 5000 ppm — agresivo. CE sustrato 1.70 mS bajo objetivo madres 3–5. ET 0.11 %/hr — apropiado para madres. **Sin estación drip-drain** — solo sensores pore_EC.

DRIP-DRAINDRIP-DRAIN

No drip-drain station deployed in MOM/PROP — substrate pore_ec sensors only

PER-PHASE BIOPHYSICS (6-week aggregates, daily-mean basis)BIOFÍSICA POR FASE (agregados 6 semanas)

Phase	FC daily mean	Floor daily mean	ET rate (%/hr dryback)	DLI (mol/m²/d)	VPD-stress hrs/d	DIF (°F)	CO₂ lights-on (ppm)	VPD lights-on (kPa)	Soil temp on / off (°F)
Mothers + Props (veg) (3d)	69.6% 67.6–73.3	60.3% 58.3–62.6	0.11 %/hr -0.05–0.27	—	0.0h 0.0–0.0	—	—	—	—

CURRENT PHASE TARGETS · Mothers + Props (veg)OBJETIVOS DE FASE ACTUAL · Mothers + Props (veg)

Feed/Drip EC: 2.5–3.5 mS Drain EC: 3.5–5.0 mS Feed pH: 5.6–5.8 Runoff pH: 5.8–6.2 Runoff %: 10–20% Dryback: 10–20% VPD lights-on: 0.8–1.1 kPa DIF: 1–3°F DLI: 25–35 mol/m²/d CO₂: 800–1500 ppm ET rate target: 0.1–0.5 %/hr

Veg West

Veg West supports flower cycles. ET rate 1.9 %/hr is healthy (young transplants pulling moisture). VPD 0.77 kPa in veg target 0.8–1.1 (low edge). DIF flat (-0.01°F). Substrate readings show massive variance — multiple zones with sensors dropping to ~0 (FC range 1.25–72.69, pore_EC range 0–30 with outlier zones). **No drip-drain station** in this room. Get a service tech in to assess the disconnected substrate sensors before this data can be trusted for daily steering.Veg West soporta ciclos de flor. ET 1.9 %/hr saludable. VPD 0.77 kPa en objetivo veg 0.8–1.1. DIF plano. Varios sensores de sustrato desconectados — datos no confiables para guía diaria. **Sin estación drip-drain**.

DRIP-DRAINDRIP-DRAIN

No drip-drain station deployed in Veg West — substrate pore_ec sensors only

PER-PHASE BIOPHYSICS (6-week aggregates, daily-mean basis)BIOFÍSICA POR FASE (agregados 6 semanas)

Phase	FC daily mean	Floor daily mean	ET rate (%/hr dryback)	DLI (mol/m²/d)	VPD-stress hrs/d	DIF (°F)	CO₂ lights-on (ppm)	VPD lights-on (kPa)	Soil temp on / off (°F)
Veg supply (Veggie Tails) (8d)	51.9% 1.2–72.7	38.9% 0.3–64.0	1.90 %/hr 0.24–8.14	—	0.4h 0.0–3.0	-0.01°F -0.35–0.29	—	0.77 ±0.119	—

CURRENT PHASE TARGETS · Veg supply (Veggie Tails)OBJETIVOS DE FASE ACTUAL · Veg supply (Veggie Tails)

Feed/Drip EC: 2.5–3.5 mS Drain EC: 3.5–5.0 mS Feed pH: 5.6–5.8 Runoff pH: 5.8–6.2 Runoff %: 10–20% Dryback: 5–15% VPD lights-on: 0.8–1.1 kPa DIF: 1–3°F DLI: 15–30 mol/m²/d CO₂: 800–1500 ppm ET rate target: 1.5–2.5 %/hr

Irrigation Event-Log Audit · 3 Priority CyclesAuditoría del Registro de Riego · 3 Ciclos Prioritarios

For each cycle, did the post-5/8 step change land within the phase target band, or did it overshoot?Para cada ciclo, ¿el cambio paso post-5/8 aterrizó dentro de la banda objetivo de la fase, o sobrepasó?

Cycle 40 Wk 4 Mega Pump · Flower East ASem 4 Mega Pump · Flower East A

	ObservedObservado	TargetObjetivo	VerdictVeredicto
Shots/d (post-5/8)	2.0	3–5	UnderBajo
Total irrigation /d	137 s	~12–20 min for runoff~12–20 min p/ runoff	Far underMuy bajo
P0 delay	136 min	90–120 min	Just longAlgo largo
Substrate EC mean	1.98	4.0–7.0	50% below50% bajo
Dryback median	19%	12–18%	At edgeEn borde

Hook: Can't generate 20–30% daily runoff (the point of bulking irrigation) on 137 s of total irrigation per day. The plants are not getting enough water to drive the EC pull-back.Diagnóstico: No puedes generar 20–30% de runoff diario (el propósito del riego de engorde) en 137 s de riego total por día. Las plantas no reciben agua suficiente para impulsar el pull-back de CE.

Cycle 39 Wk 8 Flush · Flower East BSem 8 Flush · Flower East B

	ObservedObservado	TargetObjetivo	VerdictVeredicto
Wk 5 shots/d	3.2	3–5	✓
Wk 6 shots/d	1.3	2–4	Cliff too earlyAcantilado temprano
Wk 7 shots/d	1.6	2–4	LightLigero
P0 delay post-5/8	283 min	240–300 min	✓
Substrate EC	—	6.0–8.0	Data gapDatos faltan

Hook: Ramp-down SHAPE is right but the cliff happens too early. Wk 5→6 drops 60% when ripening should be deliberately restacking EC with generative pulses. Without room readings, can't verify whether the EC restack actually happened before the final-week pull.Diagnóstico: La FORMA del descenso es correcta pero el acantilado ocurre muy temprano. Sem 5→6 cae 60% cuando maduración debería reapilar CE deliberadamente con pulsos generativos. Sin datos de sala, no se puede verificar si el restack de CE realmente ocurrió antes del tirón de la semana final.

Cycle 41 Wk 1 Transition · Flower Westt ASem 1 Transición · Flower Westt A

	ObservedObservado	TargetObjetivo	VerdictVeredicto
Shots/d post-flip	3.0	4–6	LightLigero
Mean shot duration	60 s	~180–240 s	Too smallMuy pequeño
P0 delay	299 min	120–240 min	LongLargo
P1 cadence (first 2h)	1.75 shots	4–6 shots	Will not runoffNo alcanza runoff
Substrate EC	—	6.0–12.0	Data gapDatos faltan

Hook: Classic "shots too small for first runoff in P1". 60 s on a 2 GPH × 2-emitter setup ≈ 0.27 gal per shot ≈ 3% of substrate volume — half the stretch target of 6–10%. P1 ramp will not reach FC + first runoff, which under-anchors the whole stretch.Diagnóstico: Clásico "shots muy pequeños para primer runoff en P1". 60 s en setup 2 GPH × 2 emisores ≈ 0.27 gal por shot ≈ 3% del volumen del sustrato — la mitad del objetivo de estiramiento 6–10%. La rampa P1 no alcanzará FC + primer runoff, lo que sub-ancla todo el estiramiento.

Cycle 38 · Cycle 37 CJS

C38 (370 plants, Flower West B) is in dry — not material for irrigation audit. C37 CJS (300 plants) harvested 2026-05-12. Yield numbers not yet in API (final_package_weight = null); front-end scrape blocked, so g/plant for CJS cannot be reported yet.C38 (370 plantas, Flower West B) está en seco — no relevante para auditoría de riego. C37 CJS (300 plantas) cosechado 2026-05-12. Números de rendimiento aún no en API (final_package_weight = null); raspado de front-end bloqueado, g/planta para CJS no puede reportarse aún.

Flag: Room 16868 flipped from C37 (finished 5/12) to C41 transition starting 5/7 — 5-day overlap. Worth confirming with Brittany this wasn't a hot-swap.Flag: Sala 16868 cambió de C37 (terminado 5/12) a C41 transición comenzando 5/7 — superposición de 5 días. Vale confirmar con Brittany que no fue un cambio en caliente.

Config & Guardrail AuditAuditoría de Config y Guardarrieles

Why the AROYA dashboard reads "green" while substrate EC is criticalPor qué el dashboard de AROYA lee "verde" mientras la CE del sustrato es crítica

pore_ec target_min still 3.0 in C40/C41 bulking phases. With feed EC 2.3–2.6 and "feed + 1.0" rule, lower bound should be 3.5+. As-is, substrate EC can drop to 3.0 and AROYA shows green.pore_ec target_min sigue en 3.0 en fases de engorde C40/C41. Con CE fert. 2.3–2.6 y regla "fert + 1.0", el límite inferior debería ser 3.5+. Tal como está, la CE en sustrato puede bajar a 3.0 y AROYA muestra verde.
soil_moist alert_max = 77 across all flower phases. Overnight dryback can collapse from 20% → 5% without firing any alert. This is why ZERO computed alerts fired across the whole 6-week window.soil_moist alert_max = 77 en todas las fases de flor. El dryback nocturno puede colapsar de 20% → 5% sin disparar ninguna alerta. Por eso CERO alertas calculadas se dispararon en las 6 semanas.
Flush phase pore_ec target_min = 1.0 on every cycle. Wk 8 substrate EC at 1.5 reads green even when over-leached.Flush phase pore_ec target_min = 1.0 en cada ciclo. CE sustrato en 1.5 lee verde aunque esté sobre-lixiviado.
Recipe rebuilt between C39 and C40: 18-phase template → 13-phase. The "Anchoring (Heavy DB)" phase that set early-flower root anchoring is gone from C40/C41. Veggie Tails has to absorb that work — confirm with Michael this was intentional.Receta reconstruida entre C39 y C40: plantilla 18 fases → 13 fases. La fase "Anchoring (Heavy DB)" que fijaba el anclaje radicular temprano de flor desapareció en C40/C41. Veggie Tails tiene que absorber ese trabajo — confirma con Michael que fue intencional.
Rooms 12403 + 12404 (Flower East A + B): NO room-level Coco substrate entry. Only generic SOILLESS at room level, with COCO override at phase level. Editing the room without touching the phase would silently strip substrate metadata.Salas 12403 + 12404 (Flower East A + B): SIN entrada de sustrato Coco a nivel sala. Solo SOILLESS genérico a nivel sala, con override COCO a nivel fase. Editar la sala sin tocar la fase eliminaría silenciosamente los metadatos de sustrato.
AUTOMAIT recipe (id 147112) "Automait *BURLY MAIN*" exists at 18-phase but is NOT enabled on any room/HG. Manual 13-phase template (117557) is what's running. The P0-Critical AUTOMAIT onboarding remains open.Receta AUTOMAIT (id 147112) "Automait *BURLY MAIN*" existe en 18 fases pero NO está activada en ninguna sala/HG. La plantilla manual de 13 fases (117557) es la que corre. La onboarding P0-Crítico de AUTOMAIT sigue abierta.

Recommendations — Owner-TaggedRecomendaciones — Por Responsable

MichaelCycle 40 Wk 4 Mega Pump

Push feed EC to 2.6–2.8 NOW and run 3–5 shots/day of 90–120 s each until substrate EC pulls into the 4.0–7.0 band. Allow daily runoff 20–30% — that is the point of bulking irrigation.Sube CE de fertilización a 2.6–2.8 YA y corre 3–5 shots/día de 90–120 s cada uno hasta que la CE del sustrato suba al rango 4.0–7.0. Permite runoff diario 20–30% — ese es el propósito del riego de engorde.

Direct substrate-EC sensor evidence (1.98 mean) confirms May 8 diagnosis is still active. Current 2 shots/d at 137 s total is starving the stack.Evidencia directa de sensor CE-sustrato (promedio 1.98) confirma que el diagnóstico del 8 de mayo sigue activo. Actuales 2 shots/d en 137 s total están hambruneando la pila.

MichaelC40 + C41 recipe config

Update pore_ec target_min by phase: Wk 1–3 stretch → 5.0, Wk 4–6 bulking → 3.5, Wk 7+ ripening → 6.0, final-week flush → 1.0. Update target_max similarly: 12.0 stretch, 7.0 bulking, 8.0 ripening.Actualiza pore_ec target_min por fase: Sem 1–3 estiramiento → 5.0, Sem 4–6 engorde → 3.5, Sem 7+ maduración → 6.0, flush final → 1.0. Actualiza target_max similar: 12.0 estiramiento, 7.0 engorde, 8.0 maduración.

AROYA dashboard currently shows green when EC is critically low. Aligning guardrails to the new feed plan will surface the problem visually.El dashboard de AROYA actualmente muestra verde cuando la CE es críticamente baja. Alinear guardarrieles al nuevo plan de fertilización mostrará el problema visualmente.

Michaelall flower phasestodas las fases de flor

Tighten soil_moist alert_max to ~10 pp above target FC (≈70). Set alert_min to a hard floor at (target_max − target_dryback − 5 pp) so AROYA actually alerts on dryback collapse.Aprieta soil_moist alert_max a ~10 pp arriba del FC objetivo (≈70). Pon alert_min en piso duro en (target_max − target_dryback − 5 pp) para que AROYA realmente alerte en colapso de dryback.

Zero alerts in 6 weeks is a guardrail config failure, not clean operations.Cero alertas en 6 semanas es un fallo de config de guardarrieles, no operaciones limpias.

BrittanyFlower East A 12403

Re-check HVAC overnight setpoints + under-canopy/CO₂ heater schedule. On 29 of 43 days lights-off air temp ran WARMER than lights-on. For coco bulking, target a 2–5°F drop into the dark period to drive generative signaling.Revisa setpoints HVAC nocturnos + horario de luz bajo dosel/calentador CO₂. En 29 de 43 días, temp. aire luces-off corrió MÁS CÁLIDA que luces-on. Para engorde en coco, objetivo es una caída de 2–5°F en el período oscuro para impulsar señalización generativa.

Inverse temp differential during the dark period works against the generative signal that bulking needs.El diferencial térmico invertido durante la noche trabaja contra la señal generativa que el engorde necesita.

BrittanyClimate + Feed coordinationCoordinación Clima + Fertilización

Your lowered VPDs (1.04 lights-on, low edge of band) are the right move for coco — hold them. But coordinate with Michael so feed EC rises to compensate. Lower VPD + flat feed EC = the substrate-EC collapse loop from May 8 diagnosis.Tus VPDs reducidos (1.04 luces-on, borde bajo de banda) son la jugada correcta para coco — sostenlos. Pero coordina con Michael para que la CE fert. suba para compensar. VPD bajo + CE fert. plana = el bucle de colapso CE-sustrato del diagnóstico del 8 de mayo.

VPD is a knob; substrate EC is the lever. They have to move together.El VPD es una perilla; la CE en sustrato es la palanca. Tienen que moverse juntos.

MichaelCycle 41 stretch · 16868

Triple the P1 shot size: from 60 s back to 180–240 s per shot, 4–6 shots in the first 2 h after P0 ends. Drop P0 delay to 2–3 h.Triplica el tamaño del shot P1: de 60 s a 180–240 s por shot, 4–6 shots en las primeras 2 h después de que termine P0. Baja el delay P0 a 2–3 h.

Plants need to hit FC + first runoff in P1 to anchor the stretch. Current sizing won't get there — classic "shots too small" diagnostic from the Deep Research Report.Las plantas necesitan tocar FC + primer runoff en P1 para anclar el estiramiento. El dimensionamiento actual no llega — diagnóstico clásico "shots muy pequeños" del Deep Research Report.

MichaelC42+ recipe

Restore an "Anchoring (Heavy DB)" phase between Veggie Tails and Wk 1 Transition in the rebuilt 13-phase template.Restaura una fase "Anchoring (Heavy DB)" entre Veggie Tails y Sem 1 Transición en la plantilla reconstruida de 13 fases.

Without it, root anchoring at the start of stretch is left to chance.Sin ella, el anclaje radicular al inicio del estiramiento queda al azar.

BrittanyMichaelAUTOMAIT onboarding (P0-Critical)

Schedule the missed AUTOMAIT install visit. Recipe 147112 is staged but unused. Before flipping it on, confirm runoff-threshold logic doesn't conflict with the bulking runoff strategy (the May 6 internal-consult blocker).Agenda la visita de instalación AUTOMAIT perdida. La receta 147112 está lista pero sin usar. Antes de activarla, confirma que la lógica del umbral de runoff no entra en conflicto con la estrategia de runoff en engorde (el bloqueador del 6 de mayo en consulta interna).

Recipe is ready in the library; system is not.La receta está lista en la biblioteca; el sistema no.

ProcessData integrityIntegridad de datos

Confirm whether off-AROYA irrigation events are happening on days where event log shows zero shots in active flower rooms. If yes, patch the irrigation hardware integration. If no, you have un-watered days to investigate.Confirma si hay riegos fuera-de-AROYA ocurriendo en días donde el registro muestra cero shots en salas activas de flor. Si sí, parcha la integración de hardware de riego. Si no, tienes días sin regar para investigar.

Multiple zero-shot days observed in the window across all 3 priority cycles.Múltiples días sin shots observados en la ventana en los 3 ciclos prioritarios.

Data Quality & CoverageCalidad y Cobertura de Datos

Pull blocked mid-auditPull bloqueado a mitad de auditoría
The AROYA OpenCLI bridge detached after pulling Cycle 40 (room 12403) readings. As a result, room readings for 12404 (Cycle 39 flush), 16868 (Cycle 41 stretch), 12406 (Cycle 38 dry), 12407 (MOM/PROP), 12408 (Veg West), and 12409 (R/D Flower) are missing from this audit. Chrome MCP also wasn't connected, so the front-end scrape (HG yield, batch-tank feed EC, AUTOMAIT toggle state) couldn't run. Refresh the app.aroya.io tab to restore the bridge, then re-run. El puente OpenCLI de AROYA se desconectó después de extraer lecturas del Ciclo 40 (sala 12403). Como resultado, faltan lecturas de sala para 12404 (C39 flush), 16868 (C41 estiramiento), 12406 (C38 seco), 12407 (MOM/PROP), 12408 (Veg West), y 12409 (R/D Flower) en esta auditoría. Chrome MCP tampoco estaba conectado, por lo que el raspado front-end (rendimiento HG, CE tanque, estado AUTOMAIT) no pudo correr. Refresca la pestaña app.aroya.io para restaurar el puente, luego re-ejecuta.

Cycle / RoomCiclo / Sala	PhaseFase	ConfigConfig	EventsEventos	ReadingsLecturas
C40 · Flower East A (12403)	Bulking	✓	✓	✓ 43d
C39 · Flower East B (12404)	Flush	✓	✓	⨯
C41 · Flower Westt A (16868)	Stretch	✓	✓	⨯
C38 · Flower West B (12406)	Dry	✓	—	⨯
C37 CJS · 16868	Harvested 5/12Cosechado 5/12	✓	—	⨯
Moms (151325, 152604, 153785)	Veg	✓	—	⨯

Context sourcesFuentes de contexto

Notion · Michael Fayak 5/8/2026 1:1 (commitments)Notion · 1:1 Michael Fayak 8/5/2026 (compromisos) — notion.so/35afa016
Notion · 5/6/2026 internal consult (Brittany, AUTOMAIT)Notion · consulta interna 6/5/2026 (Brittany, AUTOMAIT) — notion.so/358fa016
Notion · 12/8/2025 1:1 (phase targets baseline)Notion · 1:1 8/12/2025 (línea base objetivos por fase) — notion.so/2c3fa016
AROYA SPA · facility 3920AROYA SPA · facility 3920 — app.aroya.io/facility/3920